Premium Only Content

The Cord Bucket Method for Tangle-Free Extension Cords!
We’ll show you one of 5 ways to wind up extension cords. The Cord Bucket method is an effective way to wind and stow cords - buckets are readily available and there are several option you can do to customize your cord bucket!
#extensioncord #powercable #cablestorage
Buy your DFJ T-Shirt, Cap, or Coffee Mug at https://www.dirtfarmerjay.com/shop
This is one in a series of episodes showing different methods of winding up and/or using extension cords. In this series, we will show the daisy chain, over-and-under, figure 8, cord reel, and cord bucket approaches.
This episode features the “Cord Bucket” method. These are simple to make and easy to customize to your preferences.
No matter what method you use to wind up your cord, always get the BEST extension cord you can afford. The cheaper the cord, the stiffer it will be, especially in cold weather.
Extension cords come packaged in a coil (much like a garden hose) or looped into an oblong shape with a sleeve around the middle. For the jobsite, we recommend 14 gauge or higher. Remember, when it comes to wire gauge sizes, the smaller the number, the larger the conductors.
For that new cord, unwind and stretch it out somewhere in the sun. It can be on the lawn, sidewalk, or driveway. Leave it out for about an hour to get the cord warm so it can “relax” and lose any memory it acquired during the time it was packaged. If it’s winter when you get your cord, place the cord somewhere warm until the cord is supple. Now you wind up the cord using the method you prefer.
The basic layout of a cord bucket is a hole low on the side of the bucket that allows the male plug end to come from inside the bucket and extend long enough to plug into a wall outlet. After the hole is drilled (1-½”/38mm is typically large enough), the end is passed from the inside to the outside of the bucket to the desired length. Then, the remainder of the cord is coiled inside the bucket until the receptacle/female end is placed on the top of the coil The lid is then placed on the top to protect it from weather and such.
There are several variations and enhancements to the basic bucket. Here are a few of them:
Drill small holes in the bottom of the bucket in case water get in so it will drain out.
Add cleats to the bottom to reinforce the bucket bottom a bit and raise it of the floor.
Inset an outlet in the lid of the bucket
Use an approved weather-tight box and cable mount on the end of the cable to have more outlets to plug into. Remember, the combined draw on all the outlets can not exceed the cord rating.
Cut side-slots on the edge of the lid to make the lid easier to place and remove, but still be secure.
There is an active debate about the safety of using coiled electrical conductors. Is it safe?
The answer is a conditional “yes.” Remember, mounted cord reels are used in industrial, garage and shop settings routinely and many of these reels are government safety-agency approved. Coiled conductors in a reel are deemed safe when the total combined electrical draw on the device is lower than the rating. As a safety measure coiled cordage is always rated lower than the usual rating for the same conductor when it is uncoiled. This is because coiling conductors does introduce some resistance and resulting heat.
This is addressed by rating the cordage lower with the idea being that less current will be utilized with that particular setup.
Some tradespeople also have the practice of pulling all the cord out of the bucket because then there is no risk of resistance/heat due to coiling. Indeed.
My practice has always been to avoid coming anywhere near the capacity of the cord when running power to the jobsite. This is asking for trouble, whether the extension cord is coiled or not.
The same is true of the capacity of the circuit that you are plugging your extension cord into. If you exceed the rating, you will heat up circuits and (hopefully) trip breakers before damage is done to the electrical components.
While you’re at it, check out these OTHER methods that trade professionals use as well:
View the "Over and Under" Method Here:
View the "Daisy Chain" Method Here:
View the "Cord Reel" Method Here:
View the "Figure 8" Method Here:
JUST DO IT YOURSELF!
Instagram: https://www.instagram.com/dirtfarmerj
Facebook: https://www.facebook.com/dirtfarmerjay
-
4:11:58
The Quartering
8 hours agoOn To The Big Bosses! Act 2 Of Expedition 33
52K7 -
1:24:56
Glenn Greenwald
12 hours agoGlenn Takes Your Questions on Tulsi's Russiagate Revelations, Columbia's $200M Settlement, and More | SYSTEM UPDATE #492
140K81 -
2:11:56
megimu32
8 hours agoOTS: With Great Power: Every Spider-Man Movie Unmasked w/ @thisistheraygaming
42.9K4 -
2:38:48
WickedVirtue
8 hours agoSailing w/ The Crew
43.8K1 -
4:29:37
Meisters of Madness
10 hours agoThe Finals with Redd
46.7K1 -
1:27:11
Omar Elattar
15 hours agoThe Dating Expert: "I've Helped 4,000 Men Find LOVE!" - The #1 Alpha Trait Women Secretly Crave!
60.9K1 -
6:04:59
VOPUSARADIO
15 hours agoPOLITI-SHOCK! "END THE FED, END THE LIES & END THE DEEP STATE ONCE AND FOR ALL"!
40.4K1 -
1:43:38
LumpyPotatoX2
11 hours agoRumble Creator Round-Table - Let's Talk About It
38.9K2 -
32:38
The Mel K Show
13 hours agoMel K & Dr. James Thorp, MD | Sacrifice: The Targeting of the Most Vulnerable | 7-24-25
41K14 -
1:12:41
Donald Trump Jr.
12 hours agoFrom Crypto to AI, There's a New American Energy Revival, Interviews with Asher Genoot & Sen McCormick | TRIGGERED Ep.261
169K62