Tuning BOSCH VE Pump Jeep Cherokee XJ: Fuel Pin Installation More Power
In this video I talk about my timing issues Tuning the Bosch VE Pump on my Jeep Cherokee XJ. I also install a new fuel pin for more power!
One year ago I swapped the electronic Bosch diesel pump out of my 1999 Jeep Cherokee XJ 2.5td and swapped in an earlier 0460404078 Mechanical VE Pump. The end result was a less sensor dependant engine with better tuning for boost and more power.
Its about a year later and after running and testing the Jeep across the summer and winter the pump needed some adjustments.
I had the pump setup too retarded and the advance timing plunger was on constantly advancing the timing, but not quite enough in the piston stroke.
After disabling the plunger and manually advancing the timing by rotating the pump, its eliminated rough starts, exhaust smoke and most of all very high EGT's.
The end result is a very noticeable power gain top end in high load situations but with drastically lower EGT's by as much as 200c.
This video is in response to the messages and emails I am getting for people doing the mechanical pump swap. Hopefully this helps you get to the desired outcome faster than I did.
Hope this helps and thanks for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
VE Pump - 0460404078
425 OHV Engine Manual - https://pdfcoffee.com/jeep25tdmotorvm-pdf-free.html
VB180086 - http://www.invasionautoproducts.com/jecarrhtuva2.html
VA180069 - http://www.invasionautoproducts.com/jecarrhtuva1.html
https://www.americantechnology.co.uk/
EGR Delete - https://www.ebay.co.uk/itm/223143838975?fits=Car+Make%3AJeep%7CModel%3ACherokee&hash=item33f468c4ff:g:9v0AAOSwi1pbmnNC
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
94
views
Jeep XJ WJ Knuckle & Akebono Brake Swap FINISHED (Part 2)
In the last video I started on the Jeep XJ WJ Knuckle and Brake Swap on the Dana 30 HP. I ran into some issues with the pre 99 unit bearings and clearance between the calipers and 15" wheels.
Since getting some new parts and comments on Part 1 I have completed the WJ Knuckle swap with high steer and the larger Akebobo brakes.
Thanks for the all the comments!
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Parts List (mixed US and EU)
Brake Kit EU Link - https://www.ebay.co.uk/itm/323897303938
WJ Ball Joints EU Link - https://www.ebay.co.uk/itm/322305896946
JKS Spacers USA Link - https://www.ebay.co.uk/itm/144653066424?hash=item21adfea0b8:g:4B0AAOSwc~5a6MFS&amdata=enc%3AAQAHAAAAsKrtvKM52ANfjgeLuuYvgnu7SJRuvDoO44gA9sQmAbC%2FlMtRxxXuflanMvzPRKXu2Q7UmzrzmdWCHk2nfGevoKry6Uj07zzs5a42JOzRg%2B4RcAk1Ye5Adr51Wct8R8qUVFNZvjV6l0OzY4qmrQrZ9%2BAQ8wCmdti1vq%2FDRwysWt6eESs9PZcze2eUNg%2FtXGc9ekPPiIHHI5gqIKfsqqEIRUXM%2FRmEvPV%2F5M2zNlpxGNo6%7Ctkp%3ABk9SR4D_k9PQYQ
Steering Knuckle, LHD - Passenger - 5011976AB, Driver 5011977AB
Steering Knuckle, RHD - Passenger - 5012517AB and any LHD knuckle for the drivers side.
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
23
views
Jeep XJ WJ Knuckle & Brake Swap, OTK High Steer (Part 1)
In this video I Install the WJ Knuckles and Brakes on my Jeep Cherokee XJ while setting up OTK high steer and a wheel alignment.
I have wanted to do a WJ steering knuckle and brake swap for the last two years and I finally have all the parts to do the build. My Jeep is a RHD so It took some time to locate part 5012517AB which I found in Russia and was kindly sent over.
In this video I do the knuckle and brake swap, set up a one ton high steer setup, a wheel alignment and build some high steer sway bar brackets. Its a complete install from start and almost to finish. I'm waiting on some inner axle sleeves, outer seals and inner seals to complete the build and that will be in the next video.
Parts List (mixed US and EU)
Brake Kit EU Link - https://www.ebay.co.uk/itm/323897303938
WJ Ball Joints EU Link - https://www.ebay.co.uk/itm/322305896946
JKS Spacers USA Link - https://www.ebay.co.uk/itm/144653066424?hash=item21adfea0b8:g:4B0AAOSwc~5a6MFS&amdata=enc%3AAQAHAAAAsKrtvKM52ANfjgeLuuYvgnu7SJRuvDoO44gA9sQmAbC%2FlMtRxxXuflanMvzPRKXu2Q7UmzrzmdWCHk2nfGevoKry6Uj07zzs5a42JOzRg%2B4RcAk1Ye5Adr51Wct8R8qUVFNZvjV6l0OzY4qmrQrZ9%2BAQ8wCmdti1vq%2FDRwysWt6eESs9PZcze2eUNg%2FtXGc9ekPPiIHHI5gqIKfsqqEIRUXM%2FRmEvPV%2F5M2zNlpxGNo6%7Ctkp%3ABk9SR4D_k9PQYQ
Steering Knuckle, LHD - Passenger - 5011976AB, Driver 5011977AB
Steering Knuckle, RHD - Passenger - 5012517AB and any LHD knuckle for the drivers side.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
68
views
Solo Winter Camping in the Jeep Cherokee XJ (Overland Vlog 11)
Me and the Jeep XJ head out Overland Solo Camping into an area I haven't visited in several years. Its a place that looks very different in the winter and i'm fortunate because its been partly ploughed for logging, allowing me access from the main road.
Konditions have ranged from -32c to +1c over the last four days and the snow is changing rapidly. Its becoming dense, heavy and hard to push.
This camp is a pretty chilled one, no dramas apart from me loosing one of the best time lapses of the northern lights i've every taken...
Hope you enjoy and thanks again for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
15
views
Solo Winter Jeep XJ Camping in Deep Snow (Overland Vlog 10)
Me and the Jeep XJ head out Solo Winter Camping in deep snow. Snow Chains, winching and digging will be the letter of the day.
I got back from the UK a couple of weeks ago and saw that we have had a huge amount of snow fall while away.
Despite that I wanted to get out for a few days and two nights to explore some wilderness roads and a nature reserver about an hour from my home to decompress from the busy Christmas brake. The temperatures are dropping to -19c in the evening and the snow conditions are powdered snow on packed snow. These are good conditions for snow wheeling and chains as the snow can be pushed easily and the packed base provides good traction for the chains to grip to.
I hope you enjoy this video and thanks for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
5
views
Solo Overland Northern Europe 'SPRING TO WINTER' - 3hr Documentary
Solo Overland Scandinavia is a Long Format 3 hour Documentary comprising some of my most memorable solo trip around Northern Scandinavia over Spring, Summer, Autumn and Winter of 2022.
Video Chapters
0:00 - Introduction
1:05 - Awning Room Lake Camp - June 2022
40:12 - Bog Camp - September 2022
1:18:26 - Remote Mountain Camp - October 2022
1:42:01 - Remote Forest Camp - November 2022
2:28:20 - Remote Lake Camp - December 2022
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
14
views
Extreme Cold -25c Solo Camping In The Jeep XJ (Overland Vlog 9)
Extreme Cold -25c Solo Wilderness Jeep Camp.
Temperatures are extremely low at the moment and daylight hours are at there lowest. I venture out to one of my favourite spots to spend a couple of nights camping in my Jeep Cherokee XJ. Temperatures started at around -13c and dropped steadily to -25c in the early hours of the morning. These kind of temperatures are extreme for camping and my setup is obviously taken to its limits, including my camera gear.
Water freezes, gas bottles don't gasify well, batteries read 0 percent even though they are fully charged. My setup was never designed for such temperatures but for me personally I enjoy experiencing these difficult conditions to see where the cracks are.
Unfortunately one of the main areas I need to improve on is the insulation under my sleep mat which I underestimated due to my previous camping experiences with the 8.1 R value on the EXPED MegaMat Duo 10.
Despite trying to insulate under the mat with the what I had with me I couldn't fend of the cold for longer than a couple of hours. Insulation is needed under the mat and I have since solved this issue with a thick thermal layer which can be removed and stored in the summer.
Thanks for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
9
views
Configuring Jeep XJ Shock Travel and Bump Stops for 35's
In this video I am Configuring my Jeep XJ Shock Travel and Bump Stops for 35's.
Since my last wilderness trip I've had some big jobs to do on the Jeep XJ to ensure its reliability and performance. I've been ignoring this work for a while but after a failed front shock, badly installed rear shocks and poorly setup bump stops its time to get this thing sorted before I go out again.
In this video my aim is to move my rear shocks to the front and build an adapter to make the rears fit the front. I will also need to fit new shocks to the rear and adjust the shock angle so that the function correctly. After the travel is all set up I will get the bump stops dialed in for upward and downward travel.
Thanks for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
10
views
DIY Boost Leak Test on the Jeep XJ Diesel
In this video I build a DIY Boost Leak Tester for the Jeep XJ Diesel to check for boost leaks. I thought I would make a video since I need to do this myself. Its a pretty simple job to check for boost leaks but fixing them can be a lot of work depending on where the leak is located.
I use a hockey puck and a valve to make an adapter to fit the XJ and then charge the system with air. Make sure you use a load of soap in the water so that the bubbles are more visible.
In my case I had two leaks on my engine, one at the turbo housing and unfortunately another at the manifold gasket.
Thanks for watching
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
11
views
Solo Jeep XJ Camping in Early Winter (Overland Vlog 8)
Back into the wilderness again in the Jeep Cherokee XJ. This time i'm in a remote part of the North on a network of logging roads. Its November and the temps are beginning to drop despite it being a very mild winter so far. I'm about 500 meters up on the top of a large hill and the temps at night drop just below -7. The diesel heater is going strong and its surprisingly toasty in the roof tent although the sound is like sleeping on an airplane so I shut it off before bed.
Anyway enough of my life story, enjoy the video and see you soon!
Mike
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
21
views
My DIY Skottle Muurikka Jeep Kitchen
In this video I go over my Jeep Cherokee XJ Camp Kitchen which includes a cooking platform with removable stove and a dedicated water boiler. I cook everything on one cast iron hit plate called a Murrikka here in Sweden, or a Skottle Grill in the USA.
My setup is semi DIY as I have welded some pegs to the bottom of the 48cm Murrikka to allow the MSR stove to clip on. This allows for use with liquid gas or it can be taken off and used on an open fire. The stove can also be taken in a backpack for hiking.
The white gas that I run with the MSR stove operates across summer and winter very efficiently and its much cheaper than bottles.
I also go over some of the supportive appliances of the kitchen like the fridge, dry food storage and cutlery as well as cleaning,.
Products in this video, Non affiliate -
USA Alternative - https://www.amazon.com/Veryard-Campfire-Portable-Removable-Grilling/dp/B09W15R8BZ/ref=d_pd_day0_sccl_2_5/144-2855946-5426165?pd_rd_w=MRqg0&content-id=amzn1.sym.8ca997d7-1ea0-4c8f-9e14-a6d756b83e30&pf_rd_p=8ca997d7-1ea0-4c8f-9e14-a6d756b83e30&pf_rd_r=9XJTNQTKERJNKCR2A8RD&pd_rd_wg=jJJYK&pd_rd_r=cf28d395-c3be-47be-bfad-286d977f5e7e&pd_rd_i=B09W15R8BZ&psc=1
Muurikka - https://www.byggshop.se/utomhus/tradgard/grillar/grillwok-och-stekhall/stekhall-muurikka/p-1328112-1327743?gclid=CjwKCAjwzY2bBhB6EiwAPpUpZphm7vjlzNFUvhTWhIkr6zjRakgQFpRN6tRnEs8KB764grL4XO5cbxoC6RoQAvD_BwE
Stainless Lid - https://www.bygghemma.se/tradgard-och-utemiljo/grillar/grilltillbehor-och-grillredskap/grillock-och-grillformar/lock-muurikka-till-stekhallar-44/p-1327671?gclid=CjwKCAjwzY2bBhB6EiwAPpUpZofNQtgwp_CrSSjrU-cr2b32Fe_RaJnWz15KKCBFMTBk0zSKxyMIuBoCbw4QAvD_BwE
MSR Stove - https://scandinavianoutdoor.se/msr/utrustning/mat-utomhuskok-och-utrustning/spisar/whisperlite-universal-combo/?gclid=CjwKCAjwzY2bBhB6EiwAPpUpZt_slEbmcryT9jd3HJvWg153rFYFgzNFrQpdISx9EnyfzkPS-1T5nRoCkSkQAvD_BwE
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
11
views
Installing AUXBEAM 7x6 LED Headlights on the Jeep Cherokee XJ
I've been MIA for a couple of weeks visiting family in the UK but i'm back in Sweden preparing the XJ for the dark winter ahead. Auxbeam kindly offered me some headlights to make the jeep shine like an oncoming meteorite in the darkness and they seem to be working well.
I had some teething issues on setup because I didn't buy the kit with the relays which would have helped immensely. But now that I have installed the relays along with a new headlight switch i'm seeing 12v at the lights instead of 10v and the headlight switch isnt melting anymore.
The link below offers 15 percent off and these lights are LHD or RHD as they just produce a flat beam. They have no markings so you will need to check if you can run them or get away with running them like me.
Thanks for watching.
Lights with no Relay & 15% Off - https://auxbeam.com/products/7x6-inch-led-headlights-qp008502?utm_source=youtube&utm_medium=video&utm_campaign=QP008502&utm_term=kk20221005&utm_content=WorkshopWildernessAdventures
Lights with Relay 15% Off - https://auxbeam.com/WWS1
All Jeep Products - https://auxbeam.com/search?type=product&options%5Bunavailable_products%5D=show&options%5Bprefix%5D=last&q=jeep+cherokee
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
9
views
Solo Wilderness Camping in the Jeep XJ (Overland Vlog 7)
In this video I check out a new location that I have wanted to visit on the map. A remote wilderness location by a lake at the top of a small mountain. This location is quite high up and it can get windy, but its a quiet and beautiful place with the opportunity to see bear and elk if your lucky.
This is almost a silent video with just a bit of talking now and then.
Thanks for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
2
views
Jeep XJ Camping in the Wet Boggy Autumn (Overland Vlog 6)
I head back out again for a couple of nights into the Wilderness for some remote camping in a relaxing location by a lake.
Its Autumn and its wet at the moment so its going to be a damp couple of days. I'm trying out my diesel heater in this video also in preparation for the deep winter freeze. Hopefully It keeps down the condensation and gives me the opportunity to camp through the winter.
The Rig is pretty much complete by the stage in terms of camping gear and on board amenities so I can enjoy using it in comfort while maintaining really good offroad capability. I'm looking forward to getting out this winter, snow chains on, hitting some snow and taking in the beautiful winter landscape.
Enjoy the video and thanks for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Jim's Overland Gear at GRABmeGEAR , Discount Code is MIKE10 - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
8
views
RJ's Sway Bar Very Quick Disconnect AISIN Locking Hub: Big Upgrade for the Jeep Cherokee XJ!
A really cool Sway Bar Disconnect made by a guy called RJ in a fabrication shop in the USA. He makes some really nice things for his XJ and hes kindly sent this sway bar locking hub prototype over for me to install and test on my Jeep XJ.
Its a pretty awesome bit of kit that disconnects with an Aisin Hub so it takes just a few seconds to do. This should be a big upgrade for my XJ given that I transition between main roads, forest roads and dirt tracks on most trips.
Thanks again RJ!
Contact RJ at - rjsdesertspeedshop@gmail.com
Check out RJs Instagram - https://www.instagram.com/lil_rjs_jeep_crisis/
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
22
views
Jeep Cherokee XJ MOD Increase Fuel Tank Capacity: DIESEL ONLY
In this video I show a simple hack to increase the fuel capacity of a standard 97+ XJ tank. A chap from Instagram called John kindly told me about the hack and I thought I would give it a try. Previously I was able to pump in 72 litres of delvis into the tank and after the hack I could get in 90 litres. I could squeeze in a bit more by inserting a copper tube bent upwards inside the breather but given the lack of headroom in the tank I thought it best to leave it at breather level.
Thanks again John!
https://www.instagram.com/johnoaksxj/
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
6
views
Running the Overland Diesel Heater off the Jeeps Main Tank
About one year ago I built a portable diesel heater for winter camping trips, heating the ARB awning room and Roof Tent along with my small workshop.
despite some initial teething issues Its worked flawlessly for over a year and has probabaly run for over a 1000 hours of operation easily.
In this video its getting rehomed in a smaller box and I am tapping the fuel tank so that the heater can pull diesel from the Jeeps main tank. This means no more refueling the heater, no spilling diesel or carrying extra fuel to top the heater up. It also lightens up the rear tire carrier so I don't have a large unit on top of it.
Original Video and Build Materials in Description - https://www.youtube.com/watch?v=ophV7ShJB8E
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
24
views
Getting MORE POWER from your Jeep's 2.5 VM Diesel Engine
I've had a number of messages about the mods i've made to the Jeep Cherokee XJ and its 2.5 VM Motori 425 OHV Diesel Engine to get more power from the engine. First off I am no expert at all but I the pursuit of turd polishing and getting more out of something from its original state.
The 2.5 VM has a terrible reputation amongst some and its loved by others. Its cylinder heads were a nice idea but in practice a one piece head would have been better, but better heads are on the market and the engine can be reliable and perform very well with modifications.
I decided to keep my VM and not swap it out to see what I could do to make it more of the engine I wanted it to be.
In this video I discuss the avenues you can take to get more power from your VM without compromising the mechanical functionality of the engine.
Thanks for following this build and watching and please find the build components below -
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Full VM Build Playlist - https://www.youtube.com/watch?v=5Mzlc9XHJ6k&list=PLQQXgt9BFgARUPF53xgncZF2nlcCqJmwV
Build Components -
Turbo Materials:
GT2052 (727264-5001S) - https://www.speeding.nu/p/turbo-tillbehor/turbo/garrett/garrett-gt-serie/garrett-gt2052.html?gclid=CjwKCAiAgvKQBhBbEiwAaPQw3LmiSWL4XqMzOMnyedYl1_jMYD5nTGCRiF70Xz8tmjxD7KQz7wCNlxoC-c0QAvD_BwE
Oil Feed - M10x1.0 to 1/8 npt -https://www.streetperformance.se/product/nippel-1-8npt-till-m10x1-hane-hane?gclid=CjwKCAiApfeQBhAUEiwA7K_UH3ZDJGXTOWNhUjLVbwd4SMmW80ceQWen4RRqE4FCITe1vKmQxgNQgBoC4QAQAvD_BwE
T25 Gaskets (x2) - https://www.speeding.nu/p/turbo-tillbehor/adapter-flansar-packningar/turbin-inlopp/t25-packning.html
T25 Turbo Heat Cover - https://www.speeding.nu/p/turbo-tillbehor/turbomossa/hurricane-turbomossa-t25-kolfiber.html
Universal Oil Feed Line - https://www.ebay.co.uk/itm/273474848723?ssPageName=STRK%3AMEBIDX%3AIT&_trksid=p2060353.m2749.l2649
Intercooler Materials:
Universal 2" Intercooler Pipe Kit - https://www.ebay.co.uk/itm/153577150247?ssPageName=STRK%3AMEBIDX%3AIT&_trksid=p2060353.m2749.l2649
Universal One Sided Intercooler - https://www.ebay.co.uk/itm/255182825365?ssPageName=STRK%3AMEBIDX%3AIT&_trksid=p2060353.m2749.l2649
Gauges:
EGT Gauge - https://www.ebay.co.uk/itm/313370513296?ssPageName=STRK%3AMEBIDX%3AIT&_trksid=p2060353.m2749.l2649
Boost Gauge - https://www.speeding.nu/p/branslesystem-an-kopplingar/branslesystem-108/bransletrycksregulator/tillbehor-bransletrycksregulator/bransletrycksmatare-0-7-bar-svart.html?gclid=CjwKCAiApfeQBhAUEiwA7K_UH6keNnt7BASJxKbbqDkj-ncbZBhCAeDfw9aQozd6843CAPTbk7CNhhoC7GYQAvD_BwE
You will have to source a 1/8npt to 1/8npt Boost line -
Manifold Extension Build Materials:
Manifold Extension Pipe 90 degree (x4) - https://www.j-spec.se/motor/avgassystem/grenror/grenrorsdelar/42x3mm-90-grader-kortradieboj-rostfri-304?group=prod_prod_grp-s1%2F487
Manifold Extension Pipe Straight x1 - https://www.j-spec.se/motor/avgassystem/grenror/grenrorsdelar/42x3mm-rak-langd-300mm-rostfri-304?group=prod_prod_grp-s1%2F487
T25 Stainless Flange (x2) - https://www.speeding.nu/p/turbo-tillbehor/adapter-flansar-packningar/turbin-inlopp/t25-turboflans-rostfritt.html
Exhaust Wrap - https://www.j-spec.se/motor/varmeskydd/avgassystem/avgasbandage/avgasbandage-titanium
Intake Materials:
2" to 3" intake adapter - https://www.j-spec.se/motor/silikonslang-ror/silikonslangar/silikonslang-reducerande/silikonslang-bla-rak-koppling-76-51mm-3-2
3" aluminium 90 degree bend - https://www.j-spec.se/motor/silikonslang-ror/aluminiumror/aluminiumror/aluminiumror-90-grader-76mm-3.00
3" Silicone Coupling for Air Box - https://www.j-spec.se/motor/silikonslang-ror/silikonslangar/silikonslang/silikonslang-bla-rak-koppling-76mm-3
Universal; Air Intake CLOSED - https://www.ebay.co.uk/itm/193754722078?ssPageName=STRK%3AMEBIDX%3AIT&_trksid=p2060353.m1438.l2649
You will need to find a suitable air intake system as there are many types.
Stainless Exhaust Materials:
2.5" Flexi - https://www.j-spec.se/motor/avgassystem/avgassystem/flexror/flexror-med-anslutning-2.5-63mm
2.5" 90 degree x1 - https://www.j-spec.se/motor/avgassystem/avgassystem/rordelar/rostfritt-ror-90-grader-2.5-63.5mm
2.5" Straight - x2 https://www.j-spec.se/motor/avgassystem/avgassystem/rordelar/rostfritt-ror-rak-100cm-2.5-63.5mm
2.5" 45 degrees x1 - https://www.j-spec.se/motor/avgassystem/avgassystem/rordelar/rostfritt-ror-45-grader-2.5-63.5mm
Some materials will require sourcing at the time of construction but this is the basis of the downpipe and the first parts of the exhaust up to the silencer.
96
views
Overland Family Camping the Swedish High Coast (Höga Kusten) in our Jeep Cherokee XJ
We set off a couple of weeks ago on a little vacation to the High Coast where we spent a couple of weeks touring some popular sights and sounds on the east coast of Sweden. Its not too far from where we live but its our first time there and also our first time with all three of us in the roof tent. I bought a Wildland Normandy Auto about four weeks ago and although we have tested it on some smaller camps this will be our first real trial run of sleeping in it for multiple nights.
I didn't film the whole two weeks for obvious reasons but thought I would take the camera along for those who are interested in some of the sights around Sweden and perhaps camping with a Family.
Mike
If you come visit - https://www.hogakusten.com/en
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
13
views
Increasing the Jeep XJ Storage :Gullwing Window Aluminium Storage Boxes
I'm in between trips and the aluminium storage boxes for the gullwing windows have come in. I haven't got stuts for the system yet but the boxes should allow me to store my recovery gear and whatever else I choose in the back window compartment, saving more space inside.
I made the boxes by taking out the original window, tracing the shape of them, the adding four 100mm deep sides to each side much like a cardboard box. The local fabricators cut and bent them and that was basically it. If your going to do something like this it would probabaly be easier to get these boxes made in 3mm aluminium and bolting the hinges directly to the inside of the box rather then having them as sperate pieces.
See you on the next camp out and thanks for watching.
Mike
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
11
views
Three Days Solo Wilderness Camping in My Jeep XJ (Overland Vlog 5)
Its been ten months since I last camped in the Jeep and the build has come a long way since then. My first Summer outing of 2022 takes me to a place called Ekopark Käringberget which is located in Västerbotten Sweden. Its a beautiful place and an amazing time of year to get out and be in nature.
On this camp I'm sleeping in the ARB Awning room for three nights while trying out my drawer system, stove, battery and fridge system to see how it all works in the real world. The aim of the build was always to have a comfortable basecamp in wilderness locations while having the ability to hike, wild camp, fish and return to camp making extended trips and traveling long distances more comfortable.
Thanks for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
2
views
Jeep Cherokee XJ Overland Build Storage
In the last video I had to pull the transmission, replace the clutch and rear main seal to get the Jeep up and running again. It fortunately a success and 700 miles later the clutch is broken in and its running better than I can remember. Now the final touches with a 30" front drive shaft have been added and I have vibrationless Jeep with no oil leaks for the first time in my ownership.
In this video I show you the main camp gear on the drawer system like the battery, fridge, food storage, stoves, recovery gear and general house keeping. I have skipped on tents and sleep gear but you can see that when i'm out camping.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Affiliate Link to EcofProducts - https://uk.ecoflow.com/pages/portable-power-stations?aff=16
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
22
views
Jeep XJ Clutch Install and a Noisy AX15 and NP231
After some insane vibrations on the Jeep I had no choice but to pull the drive train for inspection. The transmission and t-case have done over 20 years of service with pretty low mileage but large tires and a high suspension lift. My first thoughts were the clutch but sadly the transmission itself had some excessive wear that would require a rebuild if used again.
I was lucky that my spare engine came with a low mileage AX15 and Np231J that have seen no offroad uses and were largely unused for many years. The condition of both were much better and with the new clutch and refaced flywheel have made a huge difference!
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
10
views
Jeep XJ No SYE Double Cardan Shaft
The Jeep Cherokee XJ 2.5td gets a new rear double cardan driveshaft today and I wanted to say a big thanks to the guys who helped out on Pateron.
Hopefully this will clear up some driveline vibrations in the rear.
The front however is absolutely terrible and sadly needs a replacement.
Thanks for watching.
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
GRABmeGEAR - https://www.grabmegear.com/
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
Finishing the Jeep XJ 2.5TD Build
Time for some final tuning before this thing is safe to drive. Intercooler Upgrade, some Turbo Wastegate Adjustments, Pressure Testing, Welding the Dana 30HP Axle Tubes, Fabricating a better Trackbar End and Changing the AX15 Transmission Oil. I probabaly could have made this into five videos but time is short and the weather is only getting better.
The jeep is finally operational and running great. There are a few small jobs to do like the SYE Driveshaft in the rear and a small repair to the front drive shaft but that's basically it. The fridge has arrived, i've built the stove and begin loading camp gear ready for our first bit of exploring and camping.
Thanks for watching!
Support me on Patreon - https://www.patreon.com/WorkshopWildernessAdventures
Check out Amazon USA - https://www.amazon.com/shop/mcqbushcraft?listId=1S3Z2JAVD999B&ref=idea_share_inf
Follow me on Instagram - https://www.instagram.com/workshopwildernessadventures/
Follow me on Facebook - https://www.facebook.com/Workshop-Wilderness-Adventures-2127584970825155
Useful Links
Offroading in Sweden - http://www.swedishepa.se/Enjoying-nature/Motor-traffic-in-nature/Off-road-4WDs-ATVs-and-motorcycles/
Road, Trail and Terrain Laws - https://www.svmc.se/smc/SMCs-arbete--fragor/Infrastruktur/Enskild-vag-led-och-terrang/
Driving Private Roads Sweden - http://www.swedishepa.se/Enjoying-nature/The-Right-of-Public-Access/Det-har-galler/Private-roads/
Wikiloc Trails - https://www.wikiloc.com/trails/offroading/sweden
Road Map - https://nvdb2012.trafikverket.se/SeTransportnatverket#
Jeep Spec:
1999 Jeep Cherokee XJ 2.5TD RHD.
Summer Tire - 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Winter Tire - Cooper Discoverer ST MAXX Por Studded 35x12.50r15 BFG KM3's with 15x8 3.75" backspacing (-19 offset).
Lift Front - RC 4.5" Coils and N2 Shocks (3" Coil Spacer).
Front Shock Bar Pin Eliminator.
Dana 30 High Pinion with Artec Industries Lower Control Arm Mounts with modified upper mount and modified Track Bar mount.
Front RC Control Arm Drop Bracket.
Ruff Stuff Short Arm Single Himes.
RC Extended Sway Bar Links.
Dana 30 Rock Crusher Diff Cover.
Ruff Stuff One Ton OTK Steering.
6" Lift Drop Pitman Arm.
Ruff Stuff Front and Center Frame Stiffeners.
Rear DIY Frame Stiffener and Rear Frame Tie in Kit.
6" x 2" Box Rocker replacement with Tube Slider.
Modified Factory Bumper with Side Sliders.
Rear Tow Hitch Tire Carrier that bolts into Rear Frame Tie in Kit.
Modified upper Shock Crossmember for Rear Shocks
Rear Axle Chrysler 8.25 29 Spline with modified High Clearance Shock Mounts.
Rear Shocks 6.5" Trailmasters.
Rear Leaf Springs 5.5" Rubicon Express
Rear RC Shackle Relocation Bracket.
Stainless Steel Braided Brake Lines front and back.
Warrior 9500lb Winch.
Front Bumper - Ebay Custom Made.
6
views